Manfred's TR1. Discussion Boards - TR1. Cylinder lower gasket oil leak

Welcome, Guest. Please Login or Register.

22.12.24 at 23:25:22

Manfred's TR1. Discussion Boards › TR1 Discussion Boards › General technical TR1 discussions
(Moderator: Manfred)

Pages: 1

TR1. Cylinder lower gasket oil leak (Read 297 times)

Badsector TR1 Board Newbie Posts: 3 Gender: Bike: TR1. 1983	TR1. Cylinder lower gasket oil leak 19.10.23 at 21:57:07 TR1. Rear cylinder lower gasket minor leak, just very little leak of oil, barely noticeable. How serious is that? I mean if that effects on pressure or so…Do I need to overhaul the engine top end immediately..? 97000 km ridden. 5A8 class of 1983.

	IP Logged

BSchneider2000 TR1 Board Full Member Posts: 168 Gender: Bike: TR1 (5A8) 130000km selbst gefahren.	Re: TR1. Cylinder lower gasket oil leak Reply #1 - 20.10.23 at 01:56:29 Hallo Badsector, ich denke, es ist an der Stelle wo die beiden Gehäusehälften zusammen stoßen. Schlimm ist es noch nicht, du musst eben 2x mehr putzen, aber beobachten. Kontrolliere vorsichtshalber einmal die Zylinderkopfschrauben ob sie noch fest sind. Bei mir lösen sie sich alle 30.000km immer etwas. Grüße Brunó I think it's at the point where the two halves of the housing meet. It's not bad yet, you just have to clean twice as much, but keep an eye on it. As a precaution, check the cylinder head screws to see if they are still tight. For me they always come loose a little every 30,000km. Greetings Brunó
	....... nur Bulldog (Hanomag) fahren ist schöner. und Motorradfahrer töten nicht, sie werden getötet.
	IP Logged

Anja-D TR1 Board Senior Member carpe diem Posts: 422 Gender: Bike: 1981 TR1. (5A8), modified with XV1100 (3LP) Eng.	Re: TR1. Cylinder lower gasket oil leak Reply #2 - 20.10.23 at 08:06:37 Good Day Badsector, could you place an image/pic of the leak here? Does your Engine was been opened during the 97000km? Perhaps is just a damaged Gasket in resuld of the age. Around the Cylindertube, on the out side, sits an orange colored O-Ring (Pos. 2). This O-Ring functioned as "Gas-Ring" and shall keep the Crank Case Blow-By Gas away from the Cylinder Food Gasket (Pos. 6). If this O-Ring is craked as result of it s age, Blow-By Gas can flow thru and results in an small Oilleak. Oil: a little amound of Engine Oil is content of the Blow-By-Gas in form of vaporised Oil. With kind regards Anja
	5A8_Cylinder.jpg Picture below may be scaled. Click link or picture for original size \| Click here for all attachments TR1 seit 1982, die aktuelle seit 1988, schraube und fahre selbst
	IP Logged

Badsector TR1 Board Newbie Posts: 3 Gender: Bike: TR1. 1983	Re: TR1. Cylinder lower gasket oil leak Reply #3 - 20.10.23 at 12:26:00 Thank You! I’ll leave the job to the future then. And check the cylinder head bolts tightness.

	IP Logged

Pages: 1

Manfred's TR1. Discussion Boards › TR1 Discussion Boards › General technical TR1 discussions
(Moderator: Manfred)